欢迎访问过程工程学报, 今天是

›› 2010, Vol. 10 ›› Issue (3): 503-507.

• 反应与分离 • 上一篇    下一篇

微波辅助制备柱撑膨润土对刚果红的吸附性能

韦科陆 唐艳葵 童张法 龙敏 梁达文   

  1. 广西大学化学化工学院 广西大学化学化工学院 广西大学化学化工学院 广西玉林师范学院
  • 收稿日期:2010-03-16 修回日期:2010-05-06 出版日期:2010-06-20 发布日期:2010-06-20
  • 通讯作者: 韦科陆

Adsorption of Congo Red from Aqueous Solution by Zr-Al Pillared Bentonite Synthesized under Microwave Irradiation

WEI Ke-lu TANG Yan-kui TONG Zhang-fa LONG Min LIANG Da-wen   

  1. School of Chemistry and Chemical Engineering, Guangxi University School of Chemistry and Chemical Engineering，Guangxi University，Nanning School of Chemistry and Chemical Engineering，Guangxi University，Nanning Yulin Teacher's College of Guangxi
  • Received:2010-03-16 Revised:2010-05-06 Online:2010-06-20 Published:2010-06-20
  • Contact: WEI Ke-lu

PDF

被引次数

35

摘要： 用微波辅助制备锆铝柱撑膨润土，考察其对废水中刚果红染料的吸附行为，并对吸附前后柱撑膨润土进行表征，以探索吸附机理. 结果表明，在原始溶液pH和室温条件下，初始浓度为50 mg/L的刚果红溶液，吸附剂用量为4 g/L时，吸附45 min后即能达到吸附平衡，柱撑膨润土的吸附容量为12.17 mg/g，脱色率达97.64%；其吸附过程符合准二级动力学方程，粒子扩散不是唯一的速率控制步骤；锆铝柱撑膨润土对刚果红的等温吸附符合Langmuir方程；XRD与FT-IR表征结果表明，吸附过程主要以物理吸附为主.

关键词: 微波辅助, 柱撑膨润土, 吸附, 刚果红

Abstract: Zr-Al pillared bentonite synthesized under microwave irradiation (MZAPB) was used as adsorbent for removal of Congo Red from wastewater. The MZAPB was characterized by XRD and FT-IR before and after adsorption of Congo Red to evaluate the possible mechanism of adsorption. The experimental results reveal that the removal rate of Congo Red can reach 97.64%, while the adsorption capacity is 12.17 mg/g, and the adsorption reaches equilibrium in 45 min when initial concentration of Congo Red is 50 mg/L, pH 5.6 and adsorbent dosage 4 g/L. The kinetic parameters of the adsorption show that the adsorption kinetics follows a pseudo-second-order model and the intraparticle diffusion is not the only rate controlling step. The Langmuir model yields a much better fitting than the Freundlich model. XRD and FT-IR data show that the physical adsorption is dominant.

Key words: microwave irradiation, pillared bentonite, adsorption, Congo Red

中图分类号: