欢迎访问过程工程学报, 今天是

过程工程学报 ›› 2016, Vol. 16 ›› Issue (3): 374-379.DOI: 10.12034/j.issn.1009-606X.215426

• 流动与传递 • 上一篇    下一篇

气固流化床中颗粒聚团的流动特性

黄亚航 刘梦溪 胡娟   

  1. 中国石油大学(北京)重质油国家重点实验室 中国石油大学(北京)重油国家重点实验室 中国石油大学(北京)重油国家重点实验室
  • 收稿日期:2015-12-28 修回日期:2016-02-04 出版日期:2016-06-20 发布日期:2017-04-28
  • 通讯作者: 刘梦溪

Flow Characteristic of Particle Agglomerates in a Gas-Solid Fluidized Bed

HUANG Ya-hang LIU Meng-xi HU Juan   

  1. State Key Laboratory of Heavy Oil, China University of Petroleum (Beijing) States Key Laboratory of Heavy Oil Processing, Chinese University of Petroleum (Beijing) States Key Laboratory of Heavy Oil Processing, Chinese University of Petroleum (Beijing)
  • Received:2015-12-28 Revised:2016-02-04 Online:2016-06-20 Published:2017-04-28
  • Contact: LIU Meng-xi

PDF

摘要： 在一套流化床冷模实验装置中研究了A类颗粒在鼓泡床和湍流床内的微观两相流动结构，测量了床层内不同轴、径向位置的瞬时固含率脉动信号，通过MATLAB软件进行解耦并统计分析求解出稠密相与稀疏相的平均固含率，以此为基础拟合了瞬时固含率信号的概率密度曲线，最后从信号中提取出颗粒聚团的有关信息. 结果表明，瞬时固含率为0.05~0.72，乳化相中颗粒聚团平均固含率为0.552~0.562. 颗粒聚团的体积分率和出现频率随表观气速增加而降低，分别为0.01~0.5和0.02~1.6 Hz，持续时间小于0.12 s.

关键词: 颗粒聚团, 固含率, 体积分率, 频率, 持续时间

Abstract: Transient solid hold-up signals were registered in a cold fluidized bed and statistically analyzed. Particle agglomerates in the emulsion phase were identified from signals and the agglomerate properties were investigated. The volume fraction of the transient solid holdup signals varied from 0.05 to 0.72. Mean solid holdup of particle agglomerates in the emulsion fluctuated in the range of 0.552~0.562, barely influenced by switch of operation pattern. The volume fraction of the particle agglomerates decreased first and then increased with increasing superficial gas velocity, varying over a range of 0.01~0.5 with flow regimes. Agglomerate frequency varied over the range of 0.02~1.6 Hz and the duration time was less than 0.12 s in most cases.

Key words: particle agglomerates, solid holdup, volume fraction, frequency, duration tim

中图分类号: