欢迎访问过程工程学报, 今天是

过程工程学报 ›› 2017, Vol. 17 ›› Issue (5): 1011-1015.DOI: 10.12034/j.issn.1009-606X.217103CSTR: 32067.14.jproeng.217103

• 过程与工艺 • 上一篇    下一篇

矿井水深度处理的阻垢方法及工艺优化

刘建军1，  张彦春2*，  李荣吉1，  王 森1，  王斌琦3     

  1. 1. 永城开控水务有限公司，河南 永城 476600；2. 北京赛科利华环境科技有限公司，北京 102208；3. 北京化工大学化学工程学院，北京 100029
  • 收稿日期:2017-01-03 修回日期:2017-02-21 出版日期:2017-10-20 发布日期:2017-10-10
  • 通讯作者: 张彦春 secolever@163.com

Anti-scaling Method and Process Optimization in the Advanced Treatment of Mine Water

Jianjun LIU1,  Yanchun ZHANG2*,  Rongji LI1,  Sen WANG1,  Binqi WANG3   

  1. 1. Yongcheng Kaikong Water Affairs Co., Ltd., Yongcheng, Henan 476600, China; 2. Beijing Secolever Environmental Science Co., Ltd., Beijing 102208, China; 3. College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
  • Received:2017-01-03 Revised:2017-02-21 Online:2017-10-20 Published:2017-10-10

PDF

被引次数

1

摘要： 针对永城开控矿井水回用项目的工艺过程及现场条件，通过理论分析、计算及实验研究，提出控制硬度、调节pH、选定最佳回收率、优选阻垢剂的综合因素分析及控制法. 结果表明，该矿井水反渗透安全经济运行的最佳进水条件为钙浓度<160 mg/L、加酸调节pH至7.4、阻垢剂加药量2.8?10?6 (?). 运行3年来反渗透膜系统结垢问题得到有效控制，压差及脱盐率变化较小.

关键词: 矿井水, 反渗透, 结垢

Abstract: According to the process and site conditions of the Yongcheng Kaikong reuse mine water project, it was suggested to control the hardness, regulate pH, select the reasonable rate of recovery and optimize the choice of antiscalant after theoretical analysis, calculation and experimental study. The optimal conditions for a safe and economical reverse osmosis system were calcium concentration lower than 160 mg/L, pH equal to 7.4, antiscalant dosage 2.8?10?6(?). The results of three-year running showed that the scaling problem has been effective controled, and the pressure difference and the desalination rate have undergone little change.

Key words: mine water, reverse osmosis, scaling