欢迎访问过程工程学报, 今天是

›› 2008, Vol. 8 ›› Issue (4): 709-713.

• 流动与传递 • 上一篇    下一篇

侧伸式气液搅拌槽内的搅拌功率与传质性能

都荣礼 黄雄斌 王昕 陈智胜   

  1. 武汉凯迪电力环保有限公司 北京化工大学化学工程学院 中国大唐集团科技工程有限公司 中国大唐集团科技工程有限公司
  • 收稿日期:2008-03-12 修回日期:2008-05-13 出版日期:2008-08-20 发布日期:2008-08-20
  • 通讯作者: 黄雄斌

Measurement of Stirring Power and Mass Transfer by a Side-entering Gas-Liquid Agitator

DOU Rong-li HUANG Xiong-bin WANG Xin CHEN Zhi-sheng   

  1. Wuhan Kaidi Electric Power Environmental CO.,LTD College of Chemical Engineering, Beijing University of Chemical Technology
  • Received:2008-03-12 Revised:2008-05-13 Online:2008-08-20 Published:2008-08-20
  • Contact: HUANG Xiong-bin

PDF

摘要： 采用f2000 mm′4200 mm侧伸式搅拌槽，研究了搅拌器的功率曲线、搅拌器数量及通气对搅拌功率的影响，结果表明，侧伸式搅拌槽内雷诺数Re在3′105时功率准数才能稳定，比立式搅拌槽内Re(104左右)高；侧伸式搅拌槽通气使搅拌器功率减小的幅度只相当于立式搅拌槽减小幅度的28%. 对侧伸式搅拌槽内喷枪式和管网式两种气体分布器的容积传质系数KLa研究结果显示，在相同搅拌功率下喷枪式分布器的传质效果是管网式分布器的近3倍；回归出了侧伸式搅拌槽内喷枪式分布器的容积传质系数KLa的关系式KLaμ(P/VL)0.161VG1.125和管网式分布器传质系数KLa的关系式KLaμVG1.778，可供工业设计参考.

关键词: 侧伸式搅拌, 功率准数, 气体分布器, 传质系数

Abstract: The influences of agitator number and superficial gas velocity on the power number were studied in a tank of f2000 mm′4200 mm with side-entering agitators. The results indicate that compared to a conventional agitated tank Reynolds number (104), a constant power number is obtained at a higher Reynolds number (3′105) and the effect of gas phase on power consumption decrease is 28% of conventional agitated tank. The gas-liquid mass transfer coefficients KLa with jet and network gas distributing devices have been investigated under same power number, and the results show that a jet gas distributing devices is about 3 times better performance of mass transfer than network gas distributing devices. The formula of mass transfer coefficient of jet gas distributing devices has been obtained as KLaμ(P/VL)0.161VG1.125, and that of network gas distributing devices is KLaμVG1.778. The investigation results provide reference to design of side-entering agitated tanks.

Key words: side-entering agitator, power number, gas distributing device, mass transfer coefficient

中图分类号: