气体管道内颗粒物在线检测特性

doi:10.12034/j.issn.1009-606X.216370

过程工程学报 ›› 2017, Vol. 17 ›› Issue (5): 965-970.DOI: 10.12034/j.issn.1009-606X.216370

气体管道内颗粒物在线检测特性

卢利锋^1,2，吴小林^1,2*，宋暄^1,2，姬忠礼^2,3

1. 中国石油大学(北京)化学工程学院，北京 102249；
2. 中国石油大学(北京)过程流体过滤与分离技术北京市重点实验室，北京 102249；
3. 中国石油大学(北京)机械与储运工程学院，北京 102249

收稿日期:2016-12-09 修回日期:2017-03-16 出版日期:2017-10-20 发布日期:2017-10-10
通讯作者: 卢利锋 LUlifeng89@163.com
基金资助:
国家重点研发计划

Characteristic of Online Measurement for Particles in Gas Pipelines

Lifeng LU^1,2, Xiaolin WU^1,2*, Xuan SONG^1,2, Zhongli JI^2,3

1. Department of Chemical Engineering, China University of Petroleum (Beijing), Beijing 102249, China;
2. Beijing Key Laboratory of Process Fluid Filtration and Separation, China University of Petroleum (Beijing), Beijing 102249, China;
3. Department of Mechanical Transportation Engineering, China University of Petroleum (Beijing), Beijing 102249, China

Received:2016-12-09 Revised:2017-03-16 Online:2017-10-20 Published:2017-10-10

摘要/Abstract

摘要： 基于Mie散射理论及热力学原理，分析颗粒物粒径检测过程中粒径通道的穿越现象，揭示了白色光源下颗粒物物性对在线检测结果的影响机制及规律. 结果表明，颗粒的吸收性会引起检测粒径发生穿越现象，粒径穿越通道数与颗粒粒径和折射率的实部与虚部密切相关. 2种吸收性颗粒(A和B)粒径的在线检测值远小于真实值，且粒径跨越了多个通道. 对粒径检测值进行修正，颗粒A和B的中位粒径分别由0.751和1.657 μm变成1.668和2.759 μm，与SEM测量结果(1.604和2.685 μm)的误差均在5%内，验证了颗粒在线检测理论及分析方法的合理性和结果的准确性，同时表明颗粒吸收性对检测结果有较大影响.

关键词: 在线检测, Mie散射理论, 白色光源, 颗粒吸收性

Abstract: Impact of physical properties of particles irradiated by white light on online measurement was explored. The shifting phenomenon of measured particle channels was analyzed based on the Mie scattering theory and thermodynamic principles. The results showed that the particle absorptivity affects the shifting of particle channels, the number of which relies greatly on the particle diameter as well as both the real and imaginary parts of refractive index. The online measurement of the diameters of two absorbing particles (A and B) reveals that the measured values (0.751 and 1.657 μm, respectively) are far smaller than their real counterparts, thus requiring further correction to the preliminary data based on the foregoing theories. Besides, particles of both types strode over multiple particle channels. The newly-corrected diameters of particle A and B transformed to be 1.668 and 2.759 μm, respectively, with an acceptable deviation of 5% as compared to the SEM result of 1.604 and 2.685 μm, which validates the rationality of the theoretical methods adopted here and further corroborates our results.

Key words: online measurement, Mie scattering theory, white light, particle absorptivity

卢利锋吴小林宋暄姬忠礼. 气体管道内颗粒物在线检测特性[J]. 过程工程学报, 2017, 17(5): 965-970.

Lifeng LU Xiaolin WU Xuan SONG Zhongli JI. Characteristic of Online Measurement for Particles in Gas Pipelines[J]. Chin. J. Process Eng., 2017, 17(5): 965-970.

参考文献

[1] 许乔奇,姬忠礼,刘刚,等.高压天然气管道内颗粒物在线检测结果校正方法[J]. 过程工程学报, 2012, 12(5):154-159.
Xu Q Q, Ji Z L, Liu G, et al. Experimental research on online determination technology of particles in high pressure natural gas pipeline[J]. Chinese Journal of Process Engineering, 2012, 12(5):870-875.
[2] 张星,姬忠礼,陈鸿海,等.高压天然气管道内粉尘在线检测方法[J]. 化工学报, 2010, 61(9):2334-2339.
Zhang X, Zhongli JI, Chen H, et al. Method of Dust On-line Measurement in High-Pressure Natural Gas Pipeline [J]. Ciesc Journal, 2010, 61(9):2334-2339.
[3] Bohren C F, Huffman D R. In Absorption and Scattering of Light by Small Particles [M]/ Absorption and scattering of light by small particles /. Wiley, 1998:3-3(1).
[4] Mishchenko M I, Lacis A A, Travis L D. Scattering, Absorption, and Emission of Light by Small Particles [M]. 2002(4):494.
[5] Umhauer H. Particle Size Distribution Analysis by Scattered Light Measurement Using an Optically Defined Measuring Volume [J]. Journal of Aerosol Science, 1983, 14(6):765-770.
[6] Umhauer H, Berbner S, Hemmer G. Optical In Situ Size and Concentration Measurement of Particlas Dispersed in Gasas at Temperaturas up to 1000°C [J]. Particle & Particle Systems Characterization, 2000, 17(1):3–15.
[7] 蔡小舒,苏明旭,沈建琪.颗粒粒度测量技术及应用[M].化学工业出版社, 2010.
[8] Yang J, Peng G, Fang G U, et al. Design of Performance Optimization for Optical Sensor in Laser Airborne Particle Counters [J]. Instrument Technique & Sensor, 2008, 37(4):59-61.
[9] Dick W D, Mcmurry P H, Weber R J, et al. White-light Detection for Nanoparticle Sizing with the TSI Ultrafine Condensation Particle Counter [J]. Journal of Nanoparticle Rasearch, 2000, 2(1):85-90.
[10]Umhauer H, Meyer J, Schiel A. A Novel Device for Single Particle Light Scattering Size Analysis and Concentration Measurement at High Pressures and Temperatures [J]. Particle & Particle Systems Characterization, 2008, 25(2):119–135.
[11]Meyer J, Umhauer H, Reuter K, et al. Concentration and Size Measurements of Fly Ash Particles from The Clean Gas Side of A Pressurised Pulverised Coal Combustion Test Facility [J]. Powder Technology, 2008, 180(1–2):57-63.
[12]Lindenthal G, L. M?lter, New White-Light Single-Particle Counter Border Zone Error nearly Eliminated, Proc. PARTEC ’98, 7th European Symp on Particle Characterization, Nürnberg, Germany, 1998, 581–590.
[13]Friehmelt, R., & Heidenreich, S. (1999). Calibration of A White-light/90° Optical Particle Counter for “Aerodynamic” Size Measurements-Experiments and Calculations for Spherical Particles and Quartz Dust [J]. Journal of Aerosol Science, 30(10), 1271-1279.
[14]Quinten M, Friehmelt R, Ebert K F. Sizing of Aggregates of Spheres by A White-light Optical Particle Counter with 90° Scattering Angle [J]. Journal of Aerosol Science, 2001, 32(1):63-72.
[15]刘蕾,王华睿,于彬,等.双层球形颗粒的光散射计算[J]. 中国粉体技术, 2008, 14(1):11-15.
Liu L, Wang H R, Bin Y U, et al. Calculation of Light Scattering by Coated Spheras [J]. China Powder Science & Technology, 2008.
[16]李丰果,杨冠玲,何振江.核壳双层颗粒的外层介质对散射光的影响[J].激光杂志, 2004, 25(4):51-52.
LI Feng-guo, Yang Guan-ling, HE Zhen-jiang. The influence of characteristics of outer layer on light scattering by a core-shell particle [J]. Laser Journal, 2004, 25(4):51-52.
[17]Stier J, Quinten M. Simple Refractive Index Correction for the Optical Particle Counter PCS 2000 by Palas [J]. Journal of Aerosol Science, 1998, 29(1–2):223-225.
[18]张寅超,杨健,陈和,等.气溶胶粒子的吸收对散射光强的影响[J].北京理工大学学报, 2015(6):612-615.
Zhang YC，J Yang，H Chen，et al. The Absorption of Aerosol Particles Impact on Scattering Intensity [J]. Journal of Beijing Institute of Technology, 2015(6):612-615.
[19]Cengel Y A, Cengel Y A. Thermodynamics [M]. McGraw-Hill Science/Engineering/Math, 2014.
[20]Heyder J, Gebhart J. Optimization of Response Functions of Light Scattering Instruments for Size Evaluation of Aerosol Particles [J]. Applied Optics, 1979, 18(5):705-11.

气体管道内颗粒物在线检测特性

Characteristic of Online Measurement for Particles in Gas Pipelines

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 1

编辑推荐

Metrics