O2/H2O气氛下CH4燃烧特性与置换天然气水合物联产方案

doi:10.12034/j.issn.1009-606X.218114

摘要/Abstract

摘要： 对O2/N2, O2/CO2和O2/H2O三种气氛下CH4燃烧特性及主要污染物生成进行了数值模拟，将出口O2浓度作为污染物排放的协同考虑因素，提出了基于O2/H2O气氛燃烧置换天然气水合物的新技术方案，比较了3种燃烧气氛对甲烷燃烧温度、燃烧速率、污染物(NOx和碳黑)生成量及燃烧效率等的影响. 结果表明，相较于O2/N2和O2/CO2气氛，O2/H2O气氛下燃烧温度最低、燃烧速率最高、污染物生成量最少、燃烧效率最高、出口O2浓度最低. 确定了与传统燃烧温度分布特征曲线相匹配的浓度配比为32vol% O2/68vol% H2O. 基于模拟研究结果，提出了一套O2/H2O燃烧技术与开发天然气水合物联产的技术新思路.

关键词: O2/H2O燃烧技术, 燃烧温度, 污染物, 天然气水合物, 联产方案

Abstract: Based on the improvement of O2/CO2 combustion technology, O2/H2O (oxy?steam) combustion technology has been widely concerned by scholars at home and abroad. Because of its advantages of small system coupling, easy start-up and low concentration of pollutants, it may become the next generation potential oxygen-rich combustion technology. At present, most studies have studied the effect of N2, CO2, and H2O(g) as diluents on the combustion characteristics of methane in single or pairwise comparisons. However, the combustion characteristics of methane in O2/N2, O2/CO2 and O2/H2O atmospheres are rarely analyzed comprehensively. And there are few researches on related applications of O2/H2O combustion technology at home and abroad. In this paper, the combustion characteristics of CH4 and the generation of main pollutants under the three atmospheres of O2/N2, O2/CO2 and O2/H2O were studied. Based on this, a new technology case based on O2/H2O atmosphere combustion and replacement of natural gas hydrates was proposed. The effects of three combustion atmospheres on combustion temperature, combustion rate, generation of pollutants (NOx, Soot), and combustion efficiency of methane were compared and analyzed. Simultaneously, the size of the outlet O2 concentration was taken as a synergistic consideration for pollutant emissions. The results showed that compared with O2/N2 and O2/CO2 atmospheres, the combustion temperature was the lowest, the combustion rate was the highest, the generation of pollutants (NOx, Soot) was the least, the combustion efficiency was the highest, and the export O2 concentration was the lowest under the atmosphere of O2/H2O. Therefore, O2/H2O combustion technology stood out. On this basis, the concentration ratio of O2/H2O matching with the characteristic curve of traditional combustion temperature distribution was determined: 32%O2/68%H2O. Based on the results of the simulation study, a new set of O2/H2O combustion technology and the development of natural gas hydrates co-production process was proposed, which can provide theoretical and technical support for future industrial applications of advanced combustion technology.

Key words: O2 / H2O (oxy-steam) combustion technology, the combustion temperature, the pollutants (NOx, Soot) generation, natural gas hydrate, co-production process

胡多多张引弟刘畅. O₂/H₂O气氛下CH₄燃烧特性与置换天然气水合物联产方案[J]. 过程工程学报, 2018, 18(5): 1102-1111.

Duoduo HU Yindi ZHANG Chang LIU. Combustion characteristics of CH₄ at O₂/H₂O atmosphere and gas hydrate co-production process[J]. Chin. J. Process Eng., 2018, 18(5): 1102-1111.

参考文献

[1] Lai X, Ye Z, Xu Z, et, al. Carbon capture andsequestration (CCS) technological innovation system in China: structure, function evaluation and policy implication. Energy Policy , 2012(50): 635–646.
[2] 刘斯亮. O2/N2、O2/CO2和O2/H2O氛围中HCN转化生成NO的特性与机理研究[D]. 华中科技大学，2016：1-2.
Liu S L. Numerical Study of HCN Oxidation Mechanism and NO Characteristic in . O2/N2、O2/CO2 and O2/H2O atmospheres[D]. Huazhong University of Science and Technology, 2016:1-2.
[3] IEA-GHG. International oxy-combustion network for CO2 capture—Report on 2ndWorkshop. CT, USA, Jan, 2007.
[4] Arlos S. Modeling design and pilot-scale experiments of CANMET’S advanced oxy-fuel/steam burner[J]. International Oxy-combustion research network, USA, 2007.
[5] 盛磊. O2/H2O和O2/CO2富氧燃烧方式下燃煤电站的模拟比较分析[D]. 华中科技大学，2015：7-9.
Sheng L. Simulation and Comparative Analysis of O2/H2O and O2/CO2 Oxy-combustion Coal-fired Power Plants[D]. Huazhong University of Science and Technology, 2015: 7-9.
[6] Yewen T, Mark A, Douglas K V. CO2 capture using oxygen enhanced combustion strategies for natural gas power plants[J]. Fuel, 2002, 81: 1007-1016．
[7] Klas A, Filip J. Flame and radiation characteristics of gas—fired O2/CO2 combustion[J]. Fuel, 2007, 86: 656-668.
[8] Seepana S, Jayanti S. Steam-moderated oxy-fuel combustion[J]. Energy Conversion and Management, 2010, 51(10): 1981-1988.
[9] Yizhuo He, Xiaochun Zheng, Jianghui Luo, et, al. Experimental and Numerical Study of the Effects of Steam Addition on NO Formation during Methane and Ammonia Oxy-Fuel Combustion[J]. Energy Fuels, 2017, 31: 10093-10100.
[10] 朱清华，牛奕，陈先锋等. 水蒸气对层流甲烷/空气扩散火焰中烟黑生成的影响[J]. 安全与环境学报，2017，17（1）：174-177.
Zhu Q H, Niu Y, Chen X F, et, al Impact of Water Vapor on the Soot Formation in the Laminar Methane/Air Diffusion Flame[J]. Journal of Safely and Environment, 2017, 17(1): 174-177.
[11] 何志霞，王谦，袁建平. 热流体数值计算方法与应用[M]. 北京：机械工业出版社，2014：9.
He Z P, Wang Q. Yuan J P. Method and Application of Numerical Calculation of Thermal Fluid[M]. Beijing: Machinery Industry Press, 2014: 9.
[12] 周力行. 湍流两相流动与燃烧的数值模拟[M]. 北京：清华大学出版社，1991：92.
Zhou L X. Numerical Simulation of Turbulent Two - Phase Flow and Combustion[M]. Beijing: Tsinghua University Press, 1991:92.
[13] 李姗. O2/CO2氛围下天然气燃烧数值模拟及热物性检测研究[D]. 长江大学，2016：24-25.
Li S. Numerical?Simulation?and?Experimental?Research for?Natural?Gas?Combustion?Characteristic?Under
O2/CO2?Atmosphere[D]. Yangtze University, 2016: 24-25.
[14] 王皆腾，祁海鹰，李宇红等. 碳氢燃料在高温空气燃烧过程中的裂解和烟炱生成[J]. 能源技术，2001，22：221-225.
Wang J T, Qi H Y, Li Y H et, al. Pyrolysis of Hydrocarbons and Soot Formation in High Temperature Air Combustion[J]. Energy Technology, 2001, 22: 221-225.
[15] 张引弟. 乙烯火焰反应动力学简化模型及烟黑生成模型研究[D]. 华中科技大学，2011:4-5.
Zhang Y D. Simulation Study on Simplification of Chemical Kinetics Model and Soot Formation for Ethylene Flames[D]. Huazhong University of Science and Technology, 2011: 4-5.
[16] Li S L, Jiang Y, Chen W T. Numerical Analysis on Characteristics of Soot Particles in ?C2H4/CO2/O2/N2 Combustion[J]. Chinese?Journal?of?Chemical?Engineering, 2013: 21(3): 238-245.
[17] 楚化强，曹文健，冯艳，等. 二氧化碳和富氧空气对甲烷与乙烯燃烧的影响[J]. 过程工程学报，2016，16（3）：470-476.
Chu H Q, Cao W J, Feng Y, et, al. Effects of CO2 and Oxygen-enriched Air on Combustion of Methane and Ethylene[J]. Journal of Process Engineering, 2016, 16(3): 470-476.
[18] Jeong P, Seung-Gon K, Kee-Man L, et, al. Chemical Effect of Diluents on Flame Structure and NO Emission Characteristic in Methane-air Counterflow Diffusion Flame[J]. International Journal of Research, 2002, 26: 1141-1160.
[19] He Y Z, Luo J H, Li Y G , et al. Comparison of the Reburning Chemistry in O2/N2，O2/CO2and O2/H2O Atmospheres[J]. Energy Fuels, 2017, 31: 11404-11412.
[20] Le C T, Dagaut P O. Oxidation of H2/CO2 mixtures and effect of hydrogen initial concentration on the combustion of CH4 and CH4/CO2 mixture Experiments and modeling[J]. Proceedings of the combustion institute , 2009, 32(1): 427-435.
[21] Giménez-López J, Millera A, Bilbao R, et, al. HCN oxidation in an O2/CO2atmosphere：An experimental and kinetic modeling study[J]. Combustion and Flame, 2010, 157(2): 267-276.
[22] Giménez-López J, Aranda V, Millera A, et, al. An experimental parametric study of gas reburning under conditions of interest for oxy-fuel combustion[J]. Fuel Processing Technology, 2011, 92(3): 582-589.
[23] 洪迪昆. CH4在O2/CO2与O2/H2O气氛下燃烧的分子动力学模拟[D]. 华中科技大学，2015：46.
Hong D K. Molecular Dynamics Simulation of Combustion of CH4 in O2/CO2 and O2/H2O Atmospheres[D]. Huazhong University of Science and Technology, 2015: 46.
[24] 徐晓英. 燃气锅炉富氧燃烧及NOX排放特性的数值模拟[D]. 吉林大学，2007：29.
Xu X Y. Numerical Simulation of Oxygen-enriched Combustion and NOX Emission Characteristic of Gas Boiler [D]. Jilin University, 2007: 29.
[25] 鄂勇，宋国利，张颖等. 碳黑大气颗粒物的环境效应[J]. 地球与环境，2006，34：61-64.
E Y, Song G L, Zhang Y et, al. Environmental Effects of Particulate Matter of Black Carbon[J]. Earth and Environment, 2006, 34: 61-64.
[26] 郭喆，娄春，刘正东. 富氧扩散火焰中燃烧特性及火焰结构对碳黑生成的影响[J]. 中国科学，2013，43（9）：991-1000.
Guo Z, Lou C, Liu Z D. Combustion Characteristics in Oxygen Diffusion Flame and Effect of Flame Structure on Carbon Black Formatio [J]. Chinese Science, 2013, 43(9): 991-1000.
[27] 田晓晶，崔玉峰，房爱兵，等. CH4/O2/H2O燃气轮机富氧燃烧特性[J]. 燃烧科学与技术，2013，19（5）：413-417.
Lian X J, Cui Y F, Fang A M, et, al. Oxy-Fuel Combustion Characteristic of CH4/O2/H2O in Gas Turbine [J]. Burning Science and Technology, 2013, 19(5): 413-417.

O₂/H₂O气氛下CH₄燃烧特性与置换天然气水合物联产方案

Combustion characteristics of CH₄ at O₂/H₂O atmosphere and gas hydrate co-production process

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	张学民李银辉张山岭张梦军李金平王英梅. 多孔介质中CO₂-CH₄水合物置换过程的强化方法研究进展[J]. 过程工程学报, 2022, 22(4): 438-447.
[2]	黄翰林刘春伟姚少杰孙峙. 废锂离子电池的热处理：过程污染物迁移和转化[J]. 过程工程学报, 2022, 22(3): 285-303.
[3]	王珂张引弟王城景辛玥. CH₄掺混H₂的燃烧数值模拟及掺混比合理性分析[J]. 过程工程学报, 2021, 21(2): 240-250.
[4]	韩健刘新华何京东. 典型煤炭燃料在民用解耦炉中的燃烧实验研究[J]. 过程工程学报, 2020, 20(6): 728-736.
[5]	宋震李凯莉孙嘉航吕忠蕾. 海洋天然气水合物储层拉削开采新方法及可行性分析[J]. 过程工程学报, 2020, 20(10): 1234-1240.
[6]	陶源清颜克凤李小森陈浩. 盐离子对蒙脱石水化膨胀特性的影响[J]. 过程工程学报, 2020, 20(10): 1182-1189.
[7]	刘仕尧黄家玉罗锦洪邓双郭凤艳. 富氧燃烧方式下烟气中SO₃和Hg的排放及控制研究进展[J]. 过程工程学报, 2019, 19(S1): 115-122.
[8]	任昕张引弟刘畅王珂. O₂/CO₂气氛中水蒸气预混CH₄燃烧特性与烟气余热梯级利用方案[J]. 过程工程学报, 2019, 19(5): 1047-1056.
[9]	李学峰何霞王国荣邱顺佐周守为刘清友. 天然气水合物提纯螺旋分离器性能数值模拟[J]. 过程工程学报, 2019, 19(3): 510-515.
[10]	于荆鑫王菁杨凤玲郝艳红程芳琴. 基于Aspen Plus的燃煤电厂烟气污染控制单元模拟[J]. 过程工程学报, 2019, 19(2): 329-337.
[11]	邱顺佐王国荣王广申周守为刘清友钟林王雷振. 旋流分离对天然气水合物除砂提纯的影响[J]. 过程工程学报, 2019, 19(1): 64-72.
[12]	陈浩吴文科吕斌陈靖文付来强尹钢. 用双锥-内锥型水力旋流器提纯海洋天然气水合物浆体[J]. 过程工程学报, 2018, 18(3): 491-495.
[13]	邢献军邢勇强虞浸李永玲马培勇许宝杰. 生活垃圾燃烧烟气中CO和NO的排放特性[J]. 过程工程学报, 2017, 17(4): 866-872.
[14]	陈彦广张雷韩洪晶赵哲吉闫伟宁宋华. 钙钛矿类混合离子电子导体在污染物处理中应用的研究进展[J]. 过程工程学报, 2015, 15(5): 892-900.
[15]	张学民李金平吴青柏王春龙南军虎. CO2置换天然气水合物中CH4的研究进展[J]. , 2014, 14(4): 715-720.