欢迎访问过程工程学报, 今天是

›› 2009, Vol. 9 ›› Issue (5): 932-939.

• 系统与集成 • 上一篇    下一篇

空分装置三吸附器TSA纯化系统及其节能效果分析

张培昆 王立 刘桂芹 李正强 杨秉彪 郭桂彬   

  1. 北京科技大学机械工程学院热能工程系 北京科技大学机械工程学院 北京科技大学机械工程学院 上海宝山钢铁公司制氧厂 酒泉钢铁公司动力厂 济钢鲍德气体有限公司
  • 收稿日期:2009-03-04 修回日期:2009-04-17 出版日期:2009-10-20 发布日期:2009-10-20
  • 通讯作者: 张培昆

Tri-adsorber TSA Purification System and Its Energy Saving Effect in Air Separation Unit

ZHANG Pei-kun WANG Li LIU Gui-qin LI Zheng-qiang YANG Bing-biao GUO Gui-bin   

  1. School of Mechanical Engineering，University of Science & Technology Beijing Mechanical Engineering School, UST Beijing Mechanical Engineering School, UST Beijing Shanghai Baosteel Co. Ltd. Power Factory， Jiuquan Iron and steel Co. Jinan Baode Gas Co. Ltd.
  • Received:2009-03-04 Revised:2009-04-17 Online:2009-10-20 Published:2009-10-20
  • Contact: ZHANG Pei-kun

PDF

摘要： 为了回收现有的双吸附器空气净化系统余热，提出了采用三吸附器空气净化系统回收利用余热，并分析了可行性. 以两工业企业20000和21000 Nm3/h制氧机为例进行初步分析计算，结果表明，若把现有系统改造为三吸附器纯化系统，可节约氮气加热电耗分别达51.3%和42.7%. 基于Aranovich-Donohue吸附等温线方程和线性驱动力传质假设的非绝热吸附模型，模型参数通过匹配生产现场监控数据确定，开发了空分变温吸附纯化系统模拟器. 基于此模拟器的数值模拟，对宝钢分公司6号制氧机双吸附器TSA系统进行三吸附器系统改造的安全性和节能效果进行了预测，安全达标情况下，节能率为45%.

关键词: 空气分离, 变温吸附, 三吸附器纯化器, 余热回收

Abstract: In order to reuse waste heat of present bi-adsorber purification system, a new tri-adsorber system was proposed to reuse the residual energy of the discharged purge gas. Energy efficiency and economic feasibility of this new system were analyzed. By general analysis and computation, the prospective rates of energy-saving could reach 58.6% and 46.1% respectively if this tri-adsorber system was applied in 20000 and 21000 Nm3/h air separation units (ASU) from two factories. An air purification temperature swing adsorption (TSA) simulator for ASUs based on Aranovich-Donohue adsorption isotherm and linear driving force (LDF) mass transfer assumed non-adiabatic adsorption model was developed, the model parameters were determined by matching monitoring curves obtained from locale industry. Safety and energy-saving effect were proved through numerical simulation if tri-adsorber TSA system was applied in No.6 ASU of Baosteel Co., Ltd., the rate of energy-saving was 45%.

Key words: air separation, temperature swing adsorption, tri-adsorber purification, exhausted heat reuse

中图分类号: