Welcome to visit The Chinese Journal of Process Engineering, Today is

Chin. J. Process Eng. ›› 2016, Vol. 16 ›› Issue (4): 622-628.DOI: 10.12034/j.issn.1009-606X.216120

• Process and Technology • Previous Articles     Next Articles

Experimental Investigation of the Influence of Ethanol on the Condensation Heat Transfer of Gravity Loop Thermosyphon without Vacuum

HUANG Jian 1,SHEN Jian-biao 1,WANG Li 2,LIU Chuan-ping 3   

  1. 1. School of Mechanical Engineering, University of Science and Technology Beijing
    2. Mechanical Engineering School, UST Beijing
    3. Mechanical Engineering School, University of Science and Technology Beijing
  • Received:2016-01-29 Revised:2016-03-16 Online:2016-08-20 Published:2016-10-10
  • Contact: HUANG Jian taurus-h@163.com

乙醇对不抽真空重力回路热虹吸管凝结换热影响的实验研究

黄建1,沈鉴彪1,王立1,刘传平2   

  1. 1. 北京科技大学机械工程学院
    2. 北京科技大学热能工程学院
  • 通讯作者: 黄建 taurus-h@163.com

Abstract: Herein we experimentally investigated the influence of ethanol on condensation heat transfer of gravity loop thermosyphon in presence of massive non-condensable gas. Investigated results revealed that addition of 0.5%?1% mass fraction of ethanol formed Marangoni effect on the surface of condensate film, promoted local condensation heat transfer, and increased 9% local heat flux of the inlet section of the condenser. When the ethanol content was greater than or equal to 1.5%, ethanol cannot fully condense to form the new non-condensable gas, the pressure of the system and temperature of evaporator could be increased, and the higher ethanol content, the higher system pressure, the system pressure of 5% condition was 64% more than pure vapor condition.

Key words: Marangoni effect, non-condensable gas, gravity loop thermosyphon, ethanol

摘要: 实验研究了添加乙醇对含大量不凝气体回路热虹吸管凝结换热的影响. 结果表明,重力回路热虹吸管内添加0.5%?1%(?)乙醇,会在凝结液膜表面形成Marangoni效应,促进局部凝结换热,冷凝管前段的局部换热量提高约9%;乙醇添加量大于1.5%时,乙醇无法完全凝结从而形成新的不凝气体,引起系统工作压力升高,蒸发器蒸汽温度升高,且乙醇含量越大,工作压力越高;乙醇含量为5%时,系统工作压力比纯水时提高64%.

关键词: Marangoni效应, 不凝气体, 重力回路热虹吸管, 乙醇

CLC Number: