用M5640从锌氨溶液中萃取锌

doi:10.12034/j.issn.1009-606X.217268

过程工程学报 ›› 2018, Vol. 18 ›› Issue (1): 103-110.DOI: 10.12034/j.issn.1009-606X.217268

用M5640从锌氨溶液中萃取锌

庄子宇，魏昶，李兴彬^*，黄卉，罗兴国，邓志敢，李存兄

昆明理工大学冶金与能源工程学院，云南昆明 650093

收稿日期:2017-06-27 修回日期:2017-09-25 出版日期:2018-02-22 发布日期:2018-01-29
通讯作者: 李兴彬 lixingbin2018@163.com
基金资助:
战略有色金属非传统资源清洁高效提取的基础研究;湿法炼锌浸出渣与高铁锌精矿协同浸出及相互作用机理研究;新型Lewis酸碱复合;压力场下高硅氧化锌矿高温酸转化及硅沉淀机理研究;从氧化锌矿氨性浸液中协同萃取锌的应用基础研究

Extraction of Zinc from Zinc Ammonia Solution by M5640

Ziyu ZHUANG, Chang WEI, Xingbin LI^*, Hui HUANG, Xingguo LUO, Zhigan DENG, Cunxiong LI

Faculty of Metallurgical and Energy Engineering, Kunming University of Science and Technology, Kunming, Yunnan 650093, China

Received:2017-06-27 Revised:2017-09-25 Online:2018-02-22 Published:2018-01-29

摘要/Abstract

摘要： 以M5640为萃取剂，在CO2协同作用下，从氨?硫酸铵溶液中萃取锌，考察了萃取剂浓度、总氨浓度、相比、温度、加入CO2等因素对锌萃取率的影响. 结果表明，M5640在氨性溶液中对锌有一定的萃取能力，溶液pH值和总氨浓度对锌的萃取率影响较大，向溶液中加入CO2可明显提高M5640对锌离子的萃取能力. 在温度25℃及M5640加入量35vol%、相比O/A=2、锌离子浓度18.02 g/L、总氨浓度3 mol/L、加入CO2的条件下，锌的单级萃取率由不加CO2时的65.1%提升至97%以上，两级错流萃取锌萃取率达99.9%. 萃取得到的有机相不含氨，表明加入CO2可避免氨的共萃.

关键词: 剂萃取, M5640, 氨性溶液, 锌

Abstract: Zinc was extracted from ammonia?ammonium sulfate solution using M5640 as an extractant. By the synergistic effect of CO2, the effects of extractant concentration, total ammonia concentration, phase ratio, temperature and addttion CO2 on the extraction rate of zinc were examined. The results showed that M5640 had a certain extraction ability to zinc from ammonia solution, and the pH value of solution and total ammonia concentration had obvious influence on the extraction rate of zinc. In the extraction process, add CO2 into solution can obviously improve the extraction efficiency of zinc. Under the conditions of temperature 25℃, M5640 concentration 35vol% O/A phase ratio of 2, zinc concentration 18.02 g/L, the total ammonia concentration in the solution 3 mol/L, with addition of CO2, zinc extraction rate increased from 65.1% (without CO2) to above 97%, by two stage cross-current extraction, zinc extraction rate reached 99.9%. The organic phase without ammonia, the results indicated that addition of CO2 can avoid co-extraction ammonia.

Key words: Solvent extraction, M5640, Ammonia solution, Zinc

庄子宇魏昶李兴彬黄卉罗兴国邓志敢李存兄. 用M5640从锌氨溶液中萃取锌[J]. 过程工程学报, 2018, 18(1): 103-110.

Ziyu ZHUANG Chang WEI Xingbin LI Hui HUANG Xingguo LUO Zhigan DENG Cunxiong LI. Extraction of Zinc from Zinc Ammonia Solution by M5640[J]. Chin. J. Process Eng., 2018, 18(1): 103-110.

参考文献

[1] 李士彬, 李宏志, 王素萍. 我国矿产资源综合利用分析及对策研究[J]. 资源与产业, 2011, 13(4): 99-104.
[2] 谭文兵, 王永生.发达国家的矿产资源战略以及对我国的启示[J].中国矿业, 2007, 16(6): 20-22.
[3] 林如海. 中国有色金属矿物资源开发现状及展望[J]. 中国金属通报, 2006, (35): 2-7.
[4] 驰骋，徐盛明，王学军，徐刚.兰坪难处理氧化锌矿选冶工艺研究进展[J].中国有色金属学报，2005, 34(4): 32-35.
[5] 蓝卓越，胡岳华.低品位氧化锌矿硫酸浸出工艺研究[J].矿业工程，2002, 22(3): 63-65
[6] 刘大星, 炳智, 蒋开喜, 王春云, 张培文.采用氨浸—萃取—电积工艺处理汤丹高碱性脉石难选氧化铜矿的试验研究和工业实践[A]// 2002年全国铜冶炼生产技术及产品应用学术交流会论文汇编[C]. 2002: 57-65.
[7] 臧宏, 温建康, 陈勃伟, 刘美林. 高碱性低品位氧化铜矿氨浸—萃取—电积工业试验[J].金属矿山. 2011(11): 87-90.
[8] CHEN Qi-yuan, LI Liang, BAI Lan, HU Hui-ping, LI Jian, LIANG Qi-wen, LING Jiang-hua. Synergistic extraction of zinc from ammoniacal ammonia sulfate solution by a mixture of a sterically hindered beta-diketone and tri-n-octylphosphine oxide (TOPO)[J]. Hydrometallurgy, 2011, 105: 201?206.
[9] 李亮. TOPO与高位阻β-二酮对氨性溶液中锌的萃取研究[D]. 长沙: 中南大学, 2011: 3-55.
[10] 凌江华，尹周澜，胡慧萍，李珊珊，胡久刚，陈启元.兰坪低品位氧化锌矿NH3- (NH4)2SO4体系浸出[J].中南大学学报(自然科学版), 2011,42(9):5-7.
[11] 张保平, 唐谟堂, 杨声海.氨法处理氧化锌矿制取电锌[J]. 中南工业大学学报(自然科学版).2003, 34(6) : 619-623.
[12] Hoh Y C, Chou N P, Wang W K. Extraction of Zinc by LIX 34[J]. Ind. Eng. Chem. Process Des. Dev. , 1982, 21(1): 12?15.
[13] Hoh Y C, Chuang W S. Influence of temperature on the extraction of zinc by LIX34[J]. Hydrometallurgy, 1983, 10(1): 123?128.
[14] Alguacil F J, Cobo A. Extraction of zinc from ammoniacal/ammonium sulphate solutions by LIX54[J]. Journal of Chemical Technology and Biotechnology, 1998, 71(2): 162?166.
[15] Alguacil F J, Alonso M. The effect of ammonium sulphate and ammonia on the liquid-liquid extraction of zinc using LIX 54[J]. Hydrometallurgy, 1999, 53(2): 203?209.
[16] 吴贤文, 尹周澜, 刘春轩, 胡慧萍, 丁治英, 陈启元. LIX84和LIX54混合萃取剂从氨性溶液中萃取锌的研究[J]. 中南大学学报(自然科学版), 2011, 42(3): 605?609.
[17] Rao K S, Sahoo P K, Jena P K. Extraction of zinc from ammoniacal solutions by hostarex DK-16[J]. Hydrometallurgy, 1992, 31(1/2): 91?100.
[18] SENGUPTA B, BHAKHAR M S, SENGUPTA R. Extraction of zinc and copper-zinc mixtures from ammoniacal solutions into emulsionliquid membranes using LIX 84I[J]. Hydrometallurgy, 2009, 99(1/2): 25?32.
[19] Kordosky G A, Virnig M J, Mattison P. Beta-diketone copper extraction: structure and stability[C]. International Solvent Extraction Conference. Cape Town, South Africa: South Africa Institute of Mining and Metallurgy. South Africa, 2002, 360?365.
[20] FU Weng, CHEN Qi-yuan, WU Qian, HU Hui-ping, BAI Lan. Solvent extraction of zinc from ammoniacal/ammonium chloride solutions by a sterically hindered β-diketone and it mixture with tri-n-octylphosphine oxide[J]. Hydrometallurgy, 2010, 100(3/4): 116?121.
[21] HU Jiu-gang, CHEN Qi-yuan, YANG Xu-ming, HU Feng-chun, HU Hui-ping, YIN Zhou-lan. Extraction of zinc from ammoniacal solution with β-diketone: A comparative study of solvents used[J]. Separation and Purification Technology, 2012, 87: 15?21.
[22] 何静, 黄玲, 陈永明, 唐谟堂, 金胜明, 冯瑞姝, 吴胜男. 新型萃取剂YORS萃取Zn(Ⅱ)-NH3配合物体系中的锌[J]. 中国有色金属学报, 2011, 21(3): 687?692.
[23] Huang L, He J, Chen Y M, Yang S H, Jin S M, Tang M T. Extraction kinetics of zinc by new extractant in ammoniacal system[J]. Journal of Central South University of Technology, 2013, (20): 1797-1804.
[24] 朱如龙, 李兴彬, 魏昶, 黄卉, 李存兄, 邓志敢, 樊刚. 采用 Mextral54-100从Zn(Ⅱ)-NH4Cl-NH3配合物溶液中萃取锌[J]. 中国有色金属学报, 2015, 25(4): 1056?1062.
[25] Tang Fu-li, Li Xing-bin, Wei Chang, Fan Gang, Zhu Ru-long, Li Cun-xiong. Synergistic extraction of zinc from ammoniacal/ammonia sulfate solution by a mixture of β-diketone and 2-hydroxy-5-nonylacetophenone oxime[J]. Hydrometallurgy, 2016, 162:42-48.
[26] 里特瑟，阿什鲁布克. 溶剂萃取原理和在冶金工艺中的应用[M].北京：原子能出版社，1985.
[27] 雷吟春, 刘云派, 朱传华. 工业用铜萃取剂研制的新进展[J].湖南有色金属, 2008, 24(2): 41-45.
[28] 陈淑萍, 赖秀华, 郭其章.M5640和Tn从酸浸出液中萃取铜试验研究[J]. 矿业工程, 2007, 27(1): 61-63.
[29] Akash Deep, Parveen Kumar, Jorge M.R. Carvalho.Recovery of copper from zinc leaching liquor using ACORGA M5640[J]. Separation and Purification Technology, 2010, 76:21-25.
[30] 汪家鼎, 陈家镛.溶剂萃取手册[M]. 北京: 化学工业出版社, 2001:53-430.
[31] 杨佼庸, 刘大星.萃取[M].北京: 冶金工业出版社, 1988:7-22.90-96.
[32] 魏志聪. 极低品位高钙氧化锌矿“冶-选”基础理论研究[D]. 昆明: 昆明理工大学, 2011: 71-109.
[33] Alguacil F J, Cobo A.Extraction of nickel from ammoniacal/ammonium carbonate solution using Acorga M5640 in Iberfluid[J]. Hydrometallurgy, 1998, 50: 143-151.
[34] Chinmay Parija, P V R. Bhaskara Sarma . Separation of nickel and copper from ammoniacal solutions through co-extraction and selective stripping uing LIX84 as the extractant[J]. Hydrometallurgy, 54, 195-204.
[35] Bina Sengupta, Mathurkumar S. Bhakhar, Ranjan Sengupta . Extraction of copper from ammoniacal solutions into emulsion liquid membranes using LIX84I?[J]. Hydrometallurgy, 1989(3/4), 311-318.
[36] D S Flett, J Melling. Extraction of ammonia by commercial copper chelating extractants[J]. Hydrometallurgy, 4(2), 135-146.
[37] K.C. Nathsarma, P.V.R. Bhaskara Sarma, Processing of ammoniacal solutions containing copper, nicke and cobalt for metal separation[J]. Hydrometallurgy, 1993,33:197-210.
[38] B.D. Pandey, V. Kumar, D. Bagchi, D.D. Akerkar, Extraction of nickel and copper from the ammoniacal leach solutions of sea nodules by LIX64N[J]. Ind. Eng. Chem. Res, 1989,28:1664-1669.
[39] Pinsent B R W, Pearson L, Roughton F J W. The Kinetics of Combination of Carbon Dioxide with Hydroxide Ions [J]. Trans.Faraday Soc., 1956, 52(11): 1512-1520.
[40] 胡久刚. 氨性溶液中铜、镍、锌金属离子的萃取行为及微观机理的研究[D]. 长沙: 中南大学，2012:74-76.

用M5640从锌氨溶液中萃取锌

Extraction of Zinc from Zinc Ammonia Solution by M5640

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	曾璐婵李雲郭宏飞张金凤曹吉林. 磷化渣废液除锌制备高纯度磷酸三钠[J]. 过程工程学报, 2022, 22(4): 478-486.
[2]	张亚卓战金辉. CH₃Cl在ZnO(001)和ZnO(100)表面吸附的第一性原理计算[J]. 过程工程学报, 2022, 22(2): 240-248.
[3]	张豪, 叶国华, 陈子杨, 谢禹, 左琪. 典型有机磷类萃取剂在溶剂萃取中协同萃取的研究进展[J]. 过程工程学报, 2021, 21(7): 741-751.
[4]	杨波童雄王晓解永刚谢贤. 从云南某高硫铅锌矿尾矿中综合回收锌的试验研究[J]. 过程工程学报, 2021, 21(6): 704-712.
[5]	张克仑李博魏永刚徐洪傲. 钒铅锌矿硫酸浸出提取钒锌[J]. 过程工程学报, 2021, 21(11): 1297-1303.
[6]	雷佛光李旻廷魏昶邓志敢李兴彬樊刚. 氧化锌烟尘碳基还原同步回收铅锡[J]. 过程工程学报, 2021, 21(11): 1304-1314.
[7]	张东张健尚广浩苏慧刘文森朱云朱兆武齐涛. 溶剂萃取法回收不锈钢酸洗废液中再生H₂SO₄的研究[J]. 过程工程学报, 2020, 20(9): 1025-1034.
[8]	纪慧超刘全军江旭董敬申. 云南高泥尾矿铅锌分离实验研究[J]. 过程工程学报, 2020, 20(8): 912-920.
[9]	黎洁纪翠翠谢贤康博文范培强. 云南某富银锌精矿锌银浮选分离实验研究[J]. 过程工程学报, 2020, 20(8): 938-946.
[10]	曾曦灿戴方钦郭悦潘卢伟柯江军巫嘉谋雷远胜李运成. 辐射管退火炉厚带钢温度场的模拟[J]. 过程工程学报, 2019, 19(4): 742-749.
[11]	罗兴国魏昶李兴彬邓志敢庄子宇李存兄. HA和HNAPO萃取锌的密度泛函分析[J]. 过程工程学报, 2019, 19(1): 151-158.
[12]	张军平陈嵩嵩盛贵阳王蕾蒋元力顾晓华张香平. 甲基丙烯酸甲酯-甲醇-水共沸体系萃取分离工艺模拟[J]. 过程工程学报, 2018, 18(6): 1323-1331.
[13]	吴东强马培勇胡淞邢献军张贤文. 污泥-锯末混合ZnCl₂活化制备活性炭[J]. 过程工程学报, 2018, 18(4): 792-798.
[14]	蔡锦鹏宋凯伟申培伦李健民刘殿文. 滇东某多金属氧化铅锌矿高效回收选矿工艺[J]. 过程工程学报, 2018, 18(3): 612-617.
[15]	刘文昭许高洁董强宁朋歌李玉平. 煤化工废水中二元酚处理方法的研究进展[J]. 过程工程学报, 2018, 18(2): 232-240.