欢迎访问过程工程学报, 今天是

›› 2015, Vol. 15 ›› Issue (2): 242-246.

• 反应与分离 • 上一篇    下一篇

针铁矿法分离铬铁矿硫酸浸出液中Cr3+与Fe3+

刘佳宁 姜茂发 李昱彤 刘美珅   

  1. 辽宁省沈阳市和平区文化路3号巷11号东北大学材冶学院825信箱 东北大学材料与冶金学院 东北大学材料与冶金学院 东北大学材料与冶金学院
  • 收稿日期:2014-12-16 修回日期:2015-02-28 出版日期:2015-05-05 发布日期:2015-05-05
  • 通讯作者: 姜茂发

Separation of Cr3+ and Fe3+ from Sulphuric Acid Leaching Solution of Chromite by Goethite Method

LIU Jia-ning JIANG Mao-fa LI Yu-tong LIU Mei-shen   

  1. Key Laboratory for Ecological Metallurgy of Multimetallic Mineral, Ministry of Education, Northeastern University School of Materials and Metallurgy, Northeastern University School of Materials and Metallurgy, Northeastern University School of Materials and Metallurgy, Northeastern University
  • Received:2014-12-16 Revised:2015-02-28 Online:2015-05-05 Published:2015-05-05
  • Contact: JIANG Mao-fa

PDF

摘要： 采用针铁矿法分离铬铁矿硫酸浸出溶液中的Cr3+与Fe3+. 结果表明，以Fe2(SO4)3溶液中加入适量KOH后生成的Fe(OH)3为前驱体，在120℃的水热条件下保温8 h后可制备出晶体发育良好的针铁矿晶种. 将铬铁矿硫酸浸出液的Fe3+浓度稀释至1 g/L以下并加入针铁矿晶种，在pH=2.5、温度90℃条件下保温4 h后，Fe3+以针铁矿晶体沉淀析出，能实现铁与铬的分离，除铁率为97%，铬损失率为33%.

关键词: 铬铁矿, 硫酸浸出, 针铁矿, Cr3+, Fe3+, 分离

Abstract: Separation of Cr3+ and Fe3+ from in sulfuric acid leaching solution of chromite with goethite was studied with experiments. The result show that Fe(OH)3 produced by adding appropriate amount of mineralizing agent (KOH) into Fe2(SO4)3 solution can be transformed into goethite inoculating crystals in good crystalline form under the conditions of 8 h heating at 120℃. After diluting the sulfuric acid leaching solution of chromite to the concentration of Fe3+ at 1 g/L and then adding goethite inoculating crystals to the solution, the separation between Fe3+ and Cr3+ can be accomplished under the conditions of pH 2.5 and 90℃ heating for 4 h. 97% of iron is precipitated and 33% of chromium lost.

Key words: chromite, sulfuric acid leaching, goethite, Cr3+, Fe3+, separation

中图分类号: